Material Safety Data Sheet

PRODUCT NAME: SUPER QUICK CLEAN GUNS

CHEMICAL NAME & SYNONYMS: SOLVENT/OIL/ADDITIVE BLEND
RECOMMENDED USE: RUST PROTECTION AND LUBRICATION

INFORMATION PHONE: 616-453-6609
EMERGENCY PHONE: 1-800-535-5053

HEALTH 1
FLAMMABILITY 1
REACTIVITY 0

I. PHYSICAL DATA & CHEMICAL DATA
BOILING POINT: N/D
VAPOR PRESSURE: > Water
SOLUBILITY IN WATER: NIL
EVAPORATION RATE: > Water
SPECIFIC GRAVITY: 0.803
PERCENT VOLATILE BY VOLUME: < 75
APPEARANCE: Amber, Clear Liquid
ODOR: Bland, mild
PHYSICAL STATE: Liquid
VAPOR DENSITY: N/D
pH CONC. (As Shipped): N/A

II. POTENTIALLY HAZARDOUS INGREDIENTS CAS #: NONE CAS #: NONE

SEE SECTIONS IX & X FOR FURTHER DATA

III. FIRE AND EXPLOSION DATA
FLASH POINT: 150 F COC
FLAMMABLE LIMITS: N/D LOWER: N/A UPPER: N/A
EXTINGUISHING MEDIA: WATER MIST, CARBON DIOXIDE, FOAM, DRY CHEMICAL
SPECIAL FIRE FIGHTING PROCEDURES:

Cool containers exposed to fire with water spray. Use self contained breathing apparatus with full face piece & protective clothing.
UNUSUAL FIRE AND EXPLOSION HAZARDS: None known

IV. REACTIVITY DATA
STABILITY: Stable
CONDITIONS TO AVOID: N/A
INCOMPATIBILITY: Oxidizing agents, acids
HAZARDOUS DECOMPOSITION PRODUCTS: Carbon dioxide, carbon monoxide, smoke, sulfur oxides,
HAZARDOUS POLYMERIZATION: Will not occur.
SUPER QUICK CLEAN GUNS EFFECTIVE DATA: 6/01/02 PAGE 2 OF 4

V. HEALTH HAZARD DATA PUBLISHED EXPOSURE LIMITS

CAS# 64742-53-6 5 MG/M3 TLV-8 HOURS

EFFECTS OF OVEREXPOSURE

ACUTE:

Inhalation: Acute effect unlikely.
Skin: Acute effect unlikely.
Eyes: Contact will cause irritation.
Ingestion: May cause upset stomach and diarrhea.

CHRONIC:

Inhalation: Long-term exposure to vapors/mists may cause pulmonary irritation, dizziness, and nausea.
Skin: Prolonged contact may cause various skin disorders.
Eyes: Prolonged contact will cause irritation.
Ingestion: Prolonged ingestion may cause upset stomach and diarrhea.

CARCINOGENICITY NTP: None IARC: None OSHA REGULATED: None
INHALATION: Remove to fresh air and provide oxygen if breathing is difficult.

INGESTION: Normally no treatment is necessary unless large volume of product is ingested. If large volume is ingested, get medical attention.

EYE CONTACT: Flush with water for 15 minutes while holding eyelids open. If irritation occurs, call a physician.

SKIN CONTACT: Wash with water and mild soap.

VI. SPILL & LEAK PROCEDURES IF MATERIAL IS RELEASED OR SPILLED:

Recover free liquid. Add clay or sand absorbent to spill area to recover residue.

WASTE DISPOSAL:

Disposal procedures must be in accordance with Local, State, and Federal Regulations.

VII. SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION: Natural ventilation normally sufficient.

LOCAL EXHAUST: N/A SPECIAL: N/A

MECHANICAL (GENERAL): For closed space OTHER: N/A

SUPER QUICK CLEAN GUNS EFFECTIVE DATA: 6/01/02 PAGE 3 OF 4

PROTECTIVE GLOVES: Chemical resistant

EYE PROTECTION: Splash goggles, face shield, or glasses.

OTHER PROTECTIVE EQUIPMENT:

Chemical apron if needed to avoid prolonged or repeated contact.

NIOSH approved respirator for organic vapor and mist to control exposure where ventilation is inadequate.

VIII. SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING:

Store between 60-90 F. Store in carbon steel tank or drums away from a source of heat or open flame.
Empty containers contain product residue. Do not cut or weld on or near container. Store in a well ventilated area.

PERSONAL HYGIENE:

Wash with soap and lots of water before meals and at end of work periods. Launder or dry-clean soiled clothing before reuse.
Discard shoes that become saturated with product.

IX. ENVIRONMENTAL REGULATIONS/FEDERAL EPA
SARA III (Superfund Amendment and Reauthorization Act of 1986)

Section 102 - Hazardous Substances:
COMPONENT RQ (lbs.) CAS# NONE

CLEAN WATER ACT:

Under section 311 (b)(4) of this act, contamination of surface waters by petroleum products must be reported
immediately to the National Response Center.

X. PRECAUTIONARY LABEL TEXT
FOR INDUSTRIAL USE ONLY.
NOT INTENDED OR SUITABLE FOR USE IN OR AROUND A HOUSEHOLD OR DWELLING.
ATTENTION:
EMPTY CONTAINERS CONTAIN PRODUCT RESIDUE, INCLUDING IGNITABLE VAPORS. DO NOT CUT OR WELD.
REFER TO MATERIAL SAFETY DATA SHEET FOR FURTHER SAFETY AND HEALTH INFORMATION.

HMIS/NFPA HAZARD: 4 = SEVERE 3 = SERIOUS 2 = MODERATE 1 = SLIGHT 0 = MINIMAL
N/D = NOT DETERMINED N/A = NOT APPLICABLE < = LESS THAN > = GREATER THAN
SUPER QUICK CLEAN GUNS EFFECTIVE DATA: 6/01/02 PAGE 4 OF 4

The information appearing in this document is based upon data obtained from raw material manufacturers and/or
recognized technical sources. While this information is believed to be correct, SCHILLINGER & ASSOCIATES INC. makes no representations as to its accuracy or sufficiency, usage, or the hazards connected with the use of this material.
Since this product may be applied under conditions unfamiliar to us or beyond our control, we claim no responsibility for the results of its use, and users are responsible for the verification of this information under their own operating conditions to determine whether this product is suitable for their particular purposes, and these users assume all risks of their use, handling, and disposal of the product. This information relates only to the product designated above and does not relate to its use in combination with any other material in any process.

SCHILLINGER & ASSOCIATES INC.
June 1, 2002